Fast and Free Shipping On Orders Over $100
No Salesmen, Just Enthusiasts 888.993.4373
Remanufactured and modified 7.3L Injectors by the best in the business, featuring brand NEW nozzles on all injector kits! If your 7.3L is losing some of its power, fuel economy, possibly getting a little hard to start, chances are that the injectors need to be replaced, and no time like the present to upgrade for more power!
Whether its time to replace the injectors due to wear or you're simply looking for some more horsepower out of your Powerstroke without needing to upgrade the turbo, these Stage 1's are a great option. When combined with a performance chip, you will typically see gains of 50-100 rear wheel horsepower, supporting up to 350HP. The stock AA injectors found in the 1994-1997 Powerstroke's flow approximately 90cc of fuel, thus the Stage 1's can double the amount of fueling if you opt for the 180cc. The 160cc flow rate is for less smoke and 20-25 horsepower less than the 180cc option. If you are running a stock turbo and have not upgraded the truck with an intercooler, it is recommended to opt for the 160cc to keep heat and smoke to a minimum. However, if you're looking for a little extra power and have upgraded your airflow, then the 180cc's will work great.
INJECTOR WARRANTY POLICY: New injectors have a 1-year warranty. Remanufactured now have an 18 month warranty. The warranty does not cover injectors that fail due to bad fuel or trash in the oil system. This also applies to the replacement of scored plungers and barrel assemblies due to bad fuel or the labor to break injectors down to clean poppet valves from dirty oil.
The buyer is to understand that these are aftermarket, high performance items, and Diesel Power Products is not responsible for any damage caused to the injectors or engine due to high EGTs, overrevving, engine failure or any other abuse or neglect.
If there is an injector problem, the buyer will have to purchase a new injector and send in the faulty injector. The buyer will receive a refund on the new injector after the faulty injector is inspected and determined to be covered by the above warranty.IMPORTANT NOTE:
- Casserly injectors are a single shot injector. Late 1996 and all 1997 California trucks run a split-shot injector from the factory. In order to switch from a split shot to a single shot injector, we recommend running custom tuning software for proper engine/fueling calibration.
- ManufacturerFull Force Diesel
- MPNFFDST1-160 | FFDST1-180
- Heavy Towing
- Light Towing
- Fuel Economy
- Mild to Moderate Performance Increase
- Stock Turbo or Slight Upgraded Turbo
- Stock Transmission
NO VIDEOS AVAILABLE